How to replace the rear brake calipers on 2006 GMC Savana 3500?

To swap out the rear brake caliper, first check the level of fluid in the reservoir of the brake master cylinder. If it is over then on the midway point between maximum-full and minimum allowable level, remove fluid to get to midway. Lift and support the vehicle, then unmount the tire and wheel assembly. Inflate the brake caliper pistons with a large c-clamp over the caliper housing top on the outboard pad rear. Tighten the clamp until pistons are moved out completely. Clean the end of the brake hose and attach a rubber cap or plug to the exposed end of the brake pipe fitting to avoid fluid leak and contamination prior to the removal of the brake hose to caliper bolt. Pop the 2 copper brake hose gaskets which might still be attached to the caliper housing or hose end and pull off the brake caliper by removing the caliper guide pin bolts. Check the caliper assembly, and when installing new brake pads, then will require you to clean the outside part of the caliper boots employing denatured alcohol and compressing pistons by the use of a c-clamp protected by a layer or a barrier. Raise the inner edge of the caliper boots to remove trapped air, allowing them to remain below the face level of the piston. Install the brake caliper onto the mounting bracket, clean the threads of the caliper guide pin bolts with brake parts cleaner, apply the threadlocker gm p/n 12345493 (Canadian P/N 10953488) followed by installing and tightening them with the guide pin bolts to 34 nm (25 ft. Lbs) for the 15 series or 72 nm (53 ft. Lbs) for the 25/35 series. Remove the rubber cap or plug, fit 2 new copper brake hose gaskets into place and connect the brake hose to the caliper bolt tighten brake hose to caliper bolt to 40 nm (30 ft. Lbs). Bleed the hydraulic brake system, remount the tire and wheel, lower the vehicle, and charge the master cylinder reservoir to the correct level with fresh brake fluid.

OEM 2006 GMC Savana 3500 Brake Calipers

Caliper

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

8 Brake Calipers found

View related parts
2006 GMC Savana 3500 Caliper
Part Number: 19331021
$170.23 MSRP: $328.77
You Save: $158.54 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Caliper, Wheel Brake Cylinder/Caliper; Brake Caliper
- Position: Rear
- Replaces: 18040101, 25848000
- Item Weight: 11.90 Pounds
- Item Dimensions: 7.2 x 4.1 x 12.6 inches
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 19331021
- Warranty: This genuine part is guaranteed by GM's factory warranty.
More Info
Fits the following 2006 GMC Savana 3500 Submodels:
- Base, LS, LT, SLE | 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL
View related parts
2006 GMC Savana 3500 Caliper
Part Number: 19331022
$171.88 MSRP: $331.97
You Save: $160.09 (49%)
ADD TO CART
Product Specifications
- Other Name: Caliper, Wheel Brake Cylinder/Caliper; Brake Caliper
- Position: Rear
- Replaces: 25848001, 18040100
- Item Weight: 11.80 Pounds
- Item Dimensions: 13.0 x 7.1 x 4.1 inches
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 19331022
- Warranty: This genuine part is guaranteed by GM's factory warranty.
More Info
Fits the following 2006 GMC Savana 3500 Submodels:
- Base, LS, LT, SLE | 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL
View related parts
2006 GMC Savana 3500 Caliper, Front Driver Side
Part Number: 84394384
$107.66 MSRP: $208.96
You Save: $101.30 (49%)
ADD TO CART
Product Specifications
- Other Name: Caliper Assembly-Front Brake (W/O Brake Pads & Bracket; Caliper, Wheel Brake Cylinder/Caliper
- Position: Front Driver Side
- Replaced by: 87859910
- Item Weight: 15.50 Pounds
- Item Dimensions: 8.4 x 5.3 x 14.4 inches
- Condition: New
- SKU: 84394384
- Warranty: This genuine part is guaranteed by GM's factory warranty.
More Info
Fits the following 2006 GMC Savana 3500 Submodels:
- Base, LS, LT, SLE | 4 Cyl 2.8 L DIESEL, 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL
View related parts
2006 GMC Savana 3500 Caliper, Passenger Side
Part Number: 84803425
$135.01 MSRP: $251.95
You Save: $116.94 (47%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Caliper Assembly-Front Brake (W/O Brake Pads & Bracket); Caliper, Wheel Brake Cylinder/Caliper
- Position: Passenger Side
- Replaced by: 87859911
- Condition: New
- SKU: 84803425
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following 2006 GMC Savana 3500 Submodels:
- Base, LS, LT, SLE | 4 Cyl 2.8 L DIESEL, 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL
View related parts
2006 GMC Savana 3500 Caliper, Front Passenger Side
Part Number: 84394392
$185.79 MSRP: $343.75
You Save: $157.96 (46%)
ADD TO CART
Product Specifications
- Other Name: Caliper Assembly-Front Brake (W/O Brake Pads & Bracket; Brake Caliper; Caliper, Wheel Brake Cylinder/Caliper
- Position: Front Passenger Side
- Replaces: 25846389, 18046220
- Item Weight: 15.70 Pounds
- Item Dimensions: 14.8 x 8.5 x 5.5 inches
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 84394392
- Warranty: This genuine part is guaranteed by GM's factory warranty.
More Info
Fits the following 2006 GMC Savana 3500 Submodels:
- Base, LS, LT, SLE | 4 Cyl 2.8 L DIESEL, 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL
View related parts
2006 GMC Savana 3500 Caliper, Rear Driver Side
Part Number: 84755503
$97.97 MSRP: $191.81
You Save: $93.84 (49%)
ADD TO CART
Product Specifications
- Other Name: Caliper Assembly-Rear Brake (W/O Brake Pads & Bracket); Brake Caliper; Caliper, Wheel Brake Cylinder/Caliper; Axle, Rear Axle
- Position: Rear Driver Side
- Replaces: 15751175, 84394396, 84046262
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 84755503
- Warranty: This genuine part is guaranteed by GM's factory warranty.
More Info
Fits the following 2006 GMC Savana 3500 Submodels:
- Base, LS, LT, SLE | 4 Cyl 2.8 L DIESEL, 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL
View related parts
2006 GMC Savana 3500 Caliper, Rear Passenger Side
Part Number: 84046263
$97.97 MSRP: $191.82
You Save: $93.85 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Caliper Assembly-Rear Brake (W/O Brake Pads & Bracket; Brake Caliper
- Position: Rear Passenger Side
- Replaced by: 84755504
- Item Weight: 11.40 Pounds
- Item Dimensions: 8.2 x 5.3 x 12.4 inches
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 84046263
- Warranty: This genuine part is guaranteed by GM's factory warranty.
More Info
Fits the following 2006 GMC Savana 3500 Submodels:
- Base, LS, LT, SLE | 4 Cyl 2.8 L DIESEL, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL
View related parts
2006 GMC Savana 3500 Caliper, Front Driver Side
Part Number: 84394391
$190.26 MSRP: $341.26
You Save: $151.00 (45%)
Product Specifications
- Other Name: Caliper Assembly-Front Brake (W/O Brake Pads & Bracket; Brake Caliper; Caliper, Wheel Brake Cylinder/Caliper
- Position: Front Driver Side
- Replaces: 18046219, 25846388
- Item Weight: 15.90 Pounds
- Item Dimensions: 14.8 x 8.5 x 5.4 inches
- Condition: New
- Fitment Type: Direct Replacement
- SKU: 84394391
- Warranty: This genuine part is guaranteed by GM's factory warranty.
More Info
Fits the following 2006 GMC Savana 3500 Submodels:
- Base, LS, LT, SLE | 4 Cyl 2.8 L DIESEL, 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 6.0 L CNG, 8 Cyl 6.0 L FLEX, 8 Cyl 6.0 L GAS, 8 Cyl 6.6 L DIESEL

2006 GMC Savana 3500 Brake Calipers

With a comprehensive array of OEM 2006 GMC Savana 3500 Brake Calipers, from fuel pumps to door handles, our website is a one-stop-shop for your needs. All our genuine 2006 GMC Savana 3500 Brake Calipers are backed by the manufacturer's warranty and are offered at competitive prices in the market. Rest assured, you can shop with complete confidence.

2006 GMC Savana 3500 Parts Questions & Experts Answers

Q: How to replace the rear brake calipers on 2006 GMC Savana 3500?
A: To swap out the rear brake caliper, first check the level of fluid in the reservoir of the brake master cylinder. If it is over then on the midway point between maximum-full and minimum allowable level, remove fluid to get to midway. Lift and support the vehicle, then unmount the tire and wheel assembly. Inflate the brake caliper pistons with a large c-clamp over the caliper housing top on the outboard pad rear. Tighten the clamp until pistons are moved out completely. Clean the end of the brake hose and attach a rubber cap or plug to the exposed end of the brake pipe fitting to avoid fluid leak and contamination prior to the removal of the brake hose to caliper bolt. Pop the 2 copper brake hose gaskets which might still be attached to the caliper housing or hose end and pull off the brake caliper by removing the caliper guide pin bolts. Check the caliper assembly, and when installing new brake pads, then will require you to clean the outside part of the caliper boots employing denatured alcohol and compressing pistons by the use of a c-clamp protected by a layer or a barrier. Raise the inner edge of the caliper boots to remove trapped air, allowing them to remain below the face level of the piston. Install the brake caliper onto the mounting bracket, clean the threads of the caliper guide pin bolts with brake parts cleaner, apply the threadlocker gm p/n 12345493 (Canadian P/N 10953488) followed by installing and tightening them with the guide pin bolts to 34 nm (25 ft. Lbs) for the 15 series or 72 nm (53 ft. Lbs) for the 25/35 series. Remove the rubber cap or plug, fit 2 new copper brake hose gaskets into place and connect the brake hose to the caliper bolt tighten brake hose to caliper bolt to 40 nm (30 ft. Lbs). Bleed the hydraulic brake system, remount the tire and wheel, lower the vehicle, and charge the master cylinder reservoir to the correct level with fresh brake fluid.

Related 2006 GMC Savana 3500 Parts

Alternate Year Models

2005 GMC Savana 3500 Brake Calipers 2007 GMC Savana 3500 Brake Calipers