How to replace the rear brake disc on a 2500 Series on Chevrolet Tahoe?

You should start by lowering the parking brake and checking brake fluid in the reservoir of a 2500 series vehicle. Only perform this step when the fluid level is set below the center mark between top and bottom indicators. After lifting the vehicle put it on stands you need to take out the tire and wheel unit while noting the disc's positioning relative to the hub. Press a large c-clamp firmly on top of the caliper housing to push in the brake caliper pistons until the piston stays fully pushed back. Remove the clamp after that. Use strong mechanic wire to hold up the brake caliper to safeguard the flexible hydraulic brake hose against damage when working above it. Work the caliper unit as one piece by cutting off the bracket bolts and moving the assembly from its location without changing the hydraulic hose. With proper clearance remove the Brake Disc retaining nuts connected to wheel studs. If needed strike the hub end with deadblow hammer to detach disc from hub before pulling off the disc from its position. Remove all rust and other materials from the hub/axle contact zone and Brake Disc installation area before working with the wheel hub resurfacing kit j-42450-a and disc resurfacing kit j-41013. Verify that mating surfaces are without debris after setting the disc at its proper location and threading it in direction of the axle. Reassemble the brake caliper system after placement but clean Brake Caliper Bracket bolt threads with brake parts cleaner and apply threadlocker gm p/n 12345493 (Canadian P/N 10953488) prior to tightening bolts to a torque of 200 nm (148 lb ft). Put the wheel back onto the tire while keeping the engine turned off then apply the brake pedal one-third of full stroke several times until you feel a firm pedal feel that correctly seats the caliper pistons into place. Add clean brake fluid to reach the recommended level in the master cylinder while fixing the brake system by running the pads and disc against each other.

OEM Chevrolet Tahoe Brake Disc

Disc Rotor

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

19 Brake Discs found

View related parts
Chevrolet Tahoe Brake Rotor
Part Number: 25757802
$152.12 MSRP: $268.83
You Save: $116.71 (44%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor, Front And Rear Wheel Brake; Rotor
- Position: Rear
- Replaces: 15712802, 15065077
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2000-2006 Chevrolet Tahoe | Base, LS, LT, Z71 | 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS
View related parts
Chevrolet Tahoe Rotor, Front
Part Number: 23144341
$124.75 MSRP: $223.77
You Save: $99.02 (45%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Replaces: 22950037, 25928787
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2020 Chevrolet Tahoe | LS, LT, LTZ, PPV | 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor, Front
Part Number: 22950036
$143.63 MSRP: $257.65
You Save: $114.02 (45%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Replaces: 88963556, 25819670
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2014 Chevrolet Tahoe | Hybrid, LS, LT, LTZ | 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor, Front
Part Number: 19210603
$102.46 MSRP: $182.96
You Save: $80.50 (44%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor, Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Replaces: 18060214
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2000-2006 Chevrolet Tahoe | Base, LS, LT, Z71 | 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS
View related parts
Chevrolet Tahoe Hub & Rotor
Part Number: 12547510
$153.29 MSRP: $286.04
You Save: $132.75 (47%)
ADD TO CART
Product Specifications
- Other Name: Rotor, Front And Rear Wheel Brake; Brake Rotor; Rotor
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1997-1999 Chevrolet Tahoe | Base, LS, LT | 8 Cyl 5.7 L GAS, 8 Cyl 6.5 L DIESEL
View related parts
Chevrolet Tahoe Rotor
Part Number: 84865905
$237.14 MSRP: $457.41
You Save: $220.27 (49%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake (Coated); Disc Brake Hardware Kit; Brake Rotor
- Position: Front
- Replaced by: 87839222
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2021-2023 Chevrolet Tahoe | PPV | 8 Cyl 5.3 L GAS
View related parts
Chevrolet Tahoe Rotor, Front
Part Number: 22950037
$124.75 MSRP: $223.77
You Save: $99.02 (45%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake; Disc Brake Hardware Kit; Brake Rotor
- Position: Front
- Replaced by: 23144341
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2014 Chevrolet Tahoe | LS, LT, LTZ | 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor
Part Number: 87839222
$237.14 MSRP: $457.41
You Save: $220.27 (49%)
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake (Coated); Rotor, Front And Rear Wheel Brake
- Replaces: 84865905
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2021-2023 Chevrolet Tahoe | Commercial, High Country, LS, LT, PPV, Premier, RST, SSV, Z71 | 6 Cyl 3.0 L DIESEL, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor, Rear
Part Number: 13552815
$116.41 MSRP: $227.91
You Save: $111.50 (49%)
ADD TO CART
Product Specifications
- Other Name: Rotor-Rear Brake (Coated); Rotor, Front And Rear Wheel Brake
- Position: Rear
- Replaces: 13531113, 13532974, 13542117, 13514114
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2021-2023 Chevrolet Tahoe | Commercial, High Country, LS, LT, Premier, RST, SSV, Z71 | 6 Cyl 3.0 L DIESEL, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor
Part Number: 13553983
$137.88 MSRP: $252.98
You Save: $115.10 (46%)
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake (Coated); Rotor, Front And Rear Wheel Brake
- Replaces: 13514522, 13542112
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2021-2022 Chevrolet Tahoe | Commercial, High Country, LS, LT, PPV, Premier, RST, SSV, Z71 | 6 Cyl 3.0 L DIESEL, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor, Rear
Part Number: 87842411
$81.22 MSRP: $156.71
You Save: $75.49 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Rear Brake (Coated); Rotor, Front And Rear Wheel Brake
- Position: Rear
- Replaces: 84582015
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2021-2023 Chevrolet Tahoe | PPV | 8 Cyl 5.3 L GAS
View related parts
Chevrolet Tahoe Rotor, Rear
Part Number: 84223345
$141.17 MSRP: $249.48
You Save: $108.31 (44%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Rear Brake; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2015-2020 Chevrolet Tahoe | PPV | 8 Cyl 5.3 L FLEX
View related parts
Chevrolet Tahoe Rotor
Part Number: 84879622
$258.96 MSRP: $503.20
You Save: $244.24 (49%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake (Coated); Rotor, Front And Rear Wheel Brake; Rotor, Brakes
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2023 Chevrolet Tahoe | Commercial, High Country, LS, LT, Premier, RST, SSV, Z71 | 6 Cyl 3.0 L DIESEL, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor, Rear
Part Number: 23195438
Product Specifications
- Other Name: Rotor-Rear Brake; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Rear
- Replaces: 22775300
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2015-2020 Chevrolet Tahoe | LS, LT, LTZ, Premier, SSV | 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor, Front
Part Number: 23144340
Product Specifications
- Other Name: Rotor-Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2015-2020 Chevrolet Tahoe | LS, LT, LTZ, Premier, SSV | 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor, Rear
Part Number: 22968231
Product Specifications
- Other Name: Rotor-Rear Brake; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Rear
- Replaces: 15792634, 25832103
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2014 Chevrolet Tahoe | Hybrid, LS, LT, LTZ | 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.2 L FLEX, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Tahoe Rotor
Part Number: 15544322
Product Specifications
- Other Name: Rotor, Front And Rear Wheel Brake; Brake Rotor
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-1996 Chevrolet Tahoe | Base, LS, LT | 8 Cyl 5.7 L GAS, 8 Cyl 6.5 L DIESEL
View related parts
Chevrolet Tahoe Hub & Rotor, Front
Part Number: 19202730
Product Specifications
- Other Name: Rotor Assembly, Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Replaces: 18060222, 19152689, 15981316
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2000 Chevrolet Tahoe | Base, Limited, LS, LT, Z71 | 8 Cyl 5.7 L GAS, 8 Cyl 6.5 L DIESEL
View related parts
Chevrolet Tahoe Rotor, Front
Part Number: 15679710
Product Specifications
- Other Name: Rotor, Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1995-2000 Chevrolet Tahoe | Base, Limited, LS, LT, Z71 | 8 Cyl 5.7 L GAS, 8 Cyl 6.5 L DIESEL

Chevrolet Tahoe Brake Disc

Our website offers an extensive catalog of genuine Chevrolet Tahoe Brake Disc at unbeatable prices. Every OEM Chevrolet Tahoe Brake Disc comes with a manufacturer's warranty, an easy return policy, and rapid delivery service. Don't miss out on this great opportunity!

Chevrolet Tahoe Brake Disc Parts Questions & Experts Answers

Rotor, Rear
22968231
Q: How to replace the rear brake disc on a 2500 Series on Chevrolet Tahoe?
A: You should start by lowering the parking brake and checking brake fluid in the reservoir of a 2500 series vehicle. Only perform this step when the fluid level is set below the center mark between top and bottom indicators. After lifting the vehicle put it on stands you need to take out the tire and wheel unit while noting the disc's positioning relative to the hub. Press a large c-clamp firmly on top of the caliper housing to push in the brake caliper pistons until the piston stays fully pushed back. Remove the clamp after that. Use strong mechanic wire to hold up the brake caliper to safeguard the flexible hydraulic brake hose against damage when working above it. Work the caliper unit as one piece by cutting off the bracket bolts and moving the assembly from its location without changing the hydraulic hose. With proper clearance remove the Brake Disc retaining nuts connected to wheel studs. If needed strike the hub end with deadblow hammer to detach disc from hub before pulling off the disc from its position. Remove all rust and other materials from the hub/axle contact zone and Brake Disc installation area before working with the wheel hub resurfacing kit j-42450-a and disc resurfacing kit j-41013. Verify that mating surfaces are without debris after setting the disc at its proper location and threading it in direction of the axle. Reassemble the brake caliper system after placement but clean Brake Caliper Bracket bolt threads with brake parts cleaner and apply threadlocker gm p/n 12345493 (Canadian P/N 10953488) prior to tightening bolts to a torque of 200 nm (148 lb ft). Put the wheel back onto the tire while keeping the engine turned off then apply the brake pedal one-third of full stroke several times until you feel a firm pedal feel that correctly seats the caliper pistons into place. Add clean brake fluid to reach the recommended level in the master cylinder while fixing the brake system by running the pads and disc against each other.