How to replace the front door hinge on GMC Savana 1500?

The first step to replace front door hinges requires you to sever the seal material surrounding them while carefully marking the hinge locations on the door and body pillar. Location each center punch mark on the hinge base using a marker after which you should create three mm pilot holes that cross through all spot welds at these marked points. Move forward with drilling a 13 mm (1/2 in) hole through both the hinge base and body pillar or door by using the smaller pilot hole. Scrape away remaining welds with a chisel so you can take off the body pillar and door units before eliminating the hinges from both components. It is essential for installation to smoothly apply the hinge by deburring holes inside the pillar and door and to check the hinge seating area for straightness. The inner and outer surfaces of the hinge pillar and Door Hinge mounting area need paint while the hinge base should receive a medium-bodied sealer. The bolt-on service replacement hinges must fit into the previous removal scribe marks before installation on the body pillar or door through the bolts joined with tapping plates that should be tightened to 5 n.m (44 lb in) initial torque. The door installation should proceed after alignment then a full closure must be avoided until you verify striker engagement before tightening all bolts to 25 n.m (18 lb ft). Sealant should be applied around the hinges before painting the entire assembly.

OEM GMC Savana 1500 Door Hinge

Interior Door Hinge

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

18 Door Hinges found

View related parts
GMC Savana 1500 Hinge, Lower
Part Number: 19257344
$155.60 MSRP: $232.63
You Save: $77.03 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Intermediate Side Door Lower (Door & Body Side); Door Hinge; Hinge Kit, Door Hinge
- Position: Lower
- Replaced by: 19540842
- Replaces: 15993408, 19210560, 19120835
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Upper
Part Number: 19257343
$169.95 MSRP: $256.38
You Save: $86.43 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Intermediate Side Door Upper (Door & Body Side); Door Hinge; Hinge Kit, Door Hinge
- Position: Upper
- Replaced by: 19540841
- Replaces: 15993404, 19120836, 19210561
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge
Part Number: 19257342
$165.54 MSRP: $247.50
You Save: $81.96 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Rear Lower
- Replaces: 15993421, 19120834, 19210562
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Rear Upper
Part Number: 19257341
$150.53 MSRP: $225.05
You Save: $74.52 (34%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Rear Side Door Upper (Door & Body Side); Door Hinge; Hinge Kit, Door Hinge
- Position: Rear Upper
- Replaced by: 19540839
- Replaces: 19120832, 19210563, 15993415
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Lower Hinge, Passenger Side
Part Number: 15994458
$239.74 MSRP: $358.42
You Save: $118.68 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Hinge, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Lower Hinge, Driver Side
Part Number: 15994457
$239.74 MSRP: $358.42
You Save: $118.68 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Hinge, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Upper Passenger Side
Part Number: 19168524
$82.44 MSRP: $159.91
You Save: $77.47 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Intermediate Side Door Upper (Body Side); Door Hinge
- Position: Upper Passenger Side
- Replaces: 15993424, 15993411, 19120833, 19120837
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2007 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Passenger Side
Part Number: 19120098
$120.75 MSRP: $172.78
You Save: $52.03 (31%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Replaces: 15993244
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Driver Side
Part Number: 19120097
$120.75 MSRP: $172.78
You Save: $52.03 (31%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Replaces: 15993243
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Upper Hinge, Passenger Side
Part Number: 15994452
$217.15 MSRP: $324.65
You Save: $107.50 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Upper Hinge, Driver Side
Part Number: 15994451
$170.16 MSRP: $243.48
You Save: $73.32 (31%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge
Part Number: 15993424
$82.44 MSRP: $159.91
You Save: $77.47 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Rear Lower
- Replaced by: 19168524
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2007 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Passenger Side
Part Number: 15993260
$129.91 MSRP: $194.22
You Save: $64.31 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Driver Side
Part Number: 15993259
$130.53 MSRP: $195.16
You Save: $64.63 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Passenger Side
Part Number: 15993238
$128.34 MSRP: $191.87
You Save: $63.53 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Driver Side
Part Number: 15993237
$128.34 MSRP: $191.87
You Save: $63.53 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Passenger Side
Part Number: 15993232
$128.34 MSRP: $191.87
You Save: $63.53 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS
View related parts
GMC Savana 1500 Hinge, Driver Side
Part Number: 15993231
$128.34 MSRP: $191.87
You Save: $63.53 (34%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Hinge Kit, Door Hinge; Door Hinge
- Position: Driver Side
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1996-2014 GMC Savana 1500 | Base, LS, LT, SLE, SLT | 6 Cyl 4.3 L GAS, 8 Cyl 5.0 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.7 L GAS

GMC Savana 1500 Door Hinge

Our website offers an extensive catalog of genuine GMC Savana 1500 Door Hinge at unbeatable prices. Every OEM GMC Savana 1500 Door Hinge comes with a manufacturer's warranty, an easy return policy, and rapid delivery service. Don't miss out on this great opportunity!

GMC Savana 1500 Door Hinge Parts Questions & Experts Answers

Lower Hinge, Driver Side
15994457
Q: How to replace the front door hinge on GMC Savana 1500?
A: The first step to replace front door hinges requires you to sever the seal material surrounding them while carefully marking the hinge locations on the door and body pillar. Location each center punch mark on the hinge base using a marker after which you should create three mm pilot holes that cross through all spot welds at these marked points. Move forward with drilling a 13 mm (1/2 in) hole through both the hinge base and body pillar or door by using the smaller pilot hole. Scrape away remaining welds with a chisel so you can take off the body pillar and door units before eliminating the hinges from both components. It is essential for installation to smoothly apply the hinge by deburring holes inside the pillar and door and to check the hinge seating area for straightness. The inner and outer surfaces of the hinge pillar and Door Hinge mounting area need paint while the hinge base should receive a medium-bodied sealer. The bolt-on service replacement hinges must fit into the previous removal scribe marks before installation on the body pillar or door through the bolts joined with tapping plates that should be tightened to 5 n.m (44 lb in) initial torque. The door installation should proceed after alignment then a full closure must be avoided until you verify striker engagement before tightening all bolts to 25 n.m (18 lb ft). Sealant should be applied around the hinges before painting the entire assembly.

Related GMC Savana 1500 Parts

Browse GMC Savana 1500 Door Hinge by Years

2014 2013 2012 2011 2010 2009 2008 2007 2006 2005 2004 2003 2002 2001 2000 1999 1998 1997 1996