How to replace the front brake disc on the 1500 Series on Chevrolet Silverado 1500?

Begin the front Brake Disc replacement process by having the rotor resurfacing kit (J 41013) and wheel hub resurfacing kit (J 42450-A). First check the brake master cylinder fluid level and drain fluid until the mark reaches the middle point. Take off the wheel and tire unit to record how the disc sits against the hub. Place two big c-clamps on the brake caliper pistons to compress them before taking out the caliper bracket bolts. Keep the caliper assembly supported below the hydraulic brake hose rather than disconnecting it. Detach the Brake Disc retaining parts from inside the wheel if necessary while putting a deadblow hammer to separate the hub or disc from each other. Remove all rust and debris from the hub/axle flange and Brake Disc contact surfaces using j 42450-a wheel hub resurfacing kit and j 41013 rotor resurfacing kit. Rephrase verbalization when possible. Check if the disc removal with jack screw method made nicks on the hub flange while inspecting the mating areas. At last place the disc over the hub and fasten it using the Brake Disc screw until the torque reaches 12nm (106 inch lbs.). The assembled lateral runout measurement of the disc should be taken, and adjustments should be made when needed. Reinstall the caliper and bracket together while applying threadlocker gm 12345493 to the bolts and tightening them to 180 nm (133 ft.lbs.). Put the tire wheel assembly back in place after lowering the vehicle and apply the brake pedal slowly with the engine stopped. Adjust caliper pistons and pads by topping up clean brake fluid when needed.

How can the assembled lateral runout (LRO) of the front brake disc be corrected on Chevrolet Silverado 1500?

To adjust the collected lateral runout (LRO) of the Brake Disc, initially ensure that an examination is done on the Brake Disc thickness, as whenever exceeded, brake pulsation is ensured. Start the measuring process by removing the conical Brake Disc washers (J 45101-100) and the lug nuts that were inserted at the time of the lro measurement. Check the mating surface of hub/axle flange and Brake Disc for any foreign particles or debris. Next, index the Brake Disc in another orientation to the resultant hub/axle flange, hold it in position and install one (1) conical Brake Disc washer (J 45101-100) and one (1) lug nut to the upper-most wheel stud, tightening the lug nut firmly by hand. Continue to retain the disc and install the balance conical Brake Disc washers (J 45101-100) and lug nuts to the brake studs with moderate hand tightening in a star shape. With the torque-limiting socket set (J 39544-KIT), torque the lug nuts in a star fashion to specification to correctly fasten the disc. Yes, take the lro that has been assembled and measure it and compare to the original prior to cleaning while keeping in mind that we have to take repeated measurements and hold it at a perpendicular alignment to obtain accurate reading. If measurement is within specifications, install the brake caliper and operate the brake pedal several times to lock the disc before installing the conical Brake Disc washers (J 45101-100) and lug nuts. When the measurement is outside specification, repeat the indexing and tightening until the best assembled lro measurement is achieved, and matchmark the final position of the disc to the wheel studs, if the orientation is differing from the original.

OEM Chevrolet Silverado 1500 Brake Disc

Disc Rotor

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

15 Brake Discs found

View related parts
Chevrolet Silverado 1500 Rotor, Rear Part Number: 23195438
$132.84 MSRP: $256.20
You Save: $123.36 (49%)
ADD TO CART
Product Specifications
- Other Name: Rotor-Rear Brake; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Rear
- Replaces: 22775300
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2014-2019 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LS, LT, LT Trail Boss, LTZ, RST, SSV, WT | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Rotor, Front Part Number: 23144340
$140.08 MSRP: $274.25
You Save: $134.17 (49%)
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2014-2019 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LS, LT, LT Trail Boss, LTZ, RST, SSV, WT | 6 Cyl 4.3 L FLEX, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 5.3 L MILD HYBRID EV-GAS (MHEV), 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Brake Rotor Part Number: 25757802
$143.40 MSRP: $274.21
You Save: $130.81 (48%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor, Front And Rear Wheel Brake; Rotor
- Position: Rear
- Replaces: 15712802, 15065077
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2002-2003 Chevrolet Silverado 1500 | Base, LS, LT, SS, WT | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Rotor Part Number: 15712803
$170.40 MSRP: $325.78
You Save: $155.38 (48%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor, Front And Rear Wheel Brake; Brake Rotor
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2004-2005 Chevrolet Silverado 1500 | Base, LS, LT, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Rotor Part Number: 15712801
$96.36 MSRP: $180.93
You Save: $84.57 (47%)
ADD TO CART
Product Specifications
- Other Name: Rotor, Front And Rear Wheel Brake; Brake Rotor
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1999-2006 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Rotor, Front Part Number: 22950036
$131.59 MSRP: $257.65
You Save: $126.06 (49%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Replaces: 88963556, 25819670
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2005-2013 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, XFE, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.0 L GAS, 8 Cyl 6.2 L FLEX
View related parts
Chevrolet Silverado 1500 Rotor, Front Part Number: 19210603
$94.27 MSRP: $182.96
You Save: $88.69 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor, Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Replaces: 18060214
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1999-2007 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Rotor, Front Part Number: 15942195
$154.61 MSRP: $302.70
You Save: $148.09 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake; Disc Brake Hardware Kit; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Front
- Replaces: 15718986, 18060215
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2001-2007 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Rotor, Rear Part Number: 13552815
$116.70 MSRP: $225.08
You Save: $108.38 (49%)
ADD TO CART
Product Specifications
- Other Name: Rotor-Rear Brake (Coated); Rotor, Front And Rear Wheel Brake
- Position: Rear
- Replaces: 13531113, 13532974, 13542117, 13514114
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2019-2023 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LT, LT Trail Boss, LTZ, PPV, RST, SSV, WT, ZR2 | 4 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Rotor Part Number: 13553983
$137.88 MSRP: $252.98
You Save: $115.10 (46%)
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake (Coated); Rotor, Front And Rear Wheel Brake
- Replaces: 13514522, 13542112
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2019-2023 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LT, LT Trail Boss, LTZ, PPV, RST, SSV, WT, ZR2 | 4 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 6 Cyl 4.3 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Rotor, Rear Part Number: 87842411
$81.22 MSRP: $157.68
You Save: $76.46 (49%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Rear Brake (Coated); Rotor, Front And Rear Wheel Brake
- Position: Rear
- Replaces: 84582015
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2022-2023 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LT, LT Trail Boss, LTZ, PPV, RST, WT, ZR2 | 4 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Rotor Part Number: 84879622
$243.85 MSRP: $464.25
You Save: $220.40 (48%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Rotor-Front Brake (Coated); Rotor, Front And Rear Wheel Brake; Rotor, Brakes
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2023 Chevrolet Silverado 1500 | Custom, Custom Trail Boss, High Country, LT, LT Trail Boss, LTZ, PPV, RST, WT, ZR2 | 4 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.2 L GAS
View related parts
Chevrolet Silverado 1500 Rotor, Rear Part Number: 22968231
Product Specifications
- Other Name: Rotor-Rear Brake; Brake Rotor; Rotor, Front And Rear Wheel Brake
- Position: Rear
- Replaces: 15792634, 25832103
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007-2013 Chevrolet Silverado 1500 | Hybrid, LS, LT, LTZ, WT, XFE | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L FLEX, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L FULL HYBRID EV-FLEX (FHEV), 8 Cyl 6.0 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 6.0 L GAS, 8 Cyl 6.2 L FLEX
View related parts
Chevrolet Silverado 1500 Rotor Part Number: 19211496
Product Specifications
- Other Name: Rotor, Front And Rear Wheel Brake; Brake Rotor
- Position: Rear
- Replaces: 15712800
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1999-2007 Chevrolet Silverado 1500 | Base, Hybrid, LS, LT, LTZ, SS, WT, Z71 Off-Road | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS
View related parts
Chevrolet Silverado 1500 Rotor Part Number: 26088273
Product Specifications
- Other Name: Rotor, Front And Rear Wheel Brake; Brake Rotor
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2006 Chevrolet Silverado 1500 | Hybrid, LS, LT, SS, WT | 6 Cyl 4.3 L GAS, 8 Cyl 4.8 L GAS, 8 Cyl 5.3 L FLEX, 8 Cyl 5.3 L FULL HYBRID EV-GAS (FHEV), 8 Cyl 5.3 L GAS, 8 Cyl 6.0 L GAS

Chevrolet Silverado 1500 Brake Disc

Want to cut long-term maintenance and repair costs? Choose OEM Brake Disc. Those parts deliver top durability you can trust. On our site, you'll find a huge catalog of genuine Chevrolet Silverado 1500 parts. Prices are unbeatable, so you can keep more in your pocket. Every OEM Chevrolet Silverado 1500 Brake Disc includes a manufacturer's warranty. You can also get an easy return policy that keeps buying risk free. Fast delivery, get your car on the road quickly. It's simple to search, compare, and order. Stop guessing about quality or fit. Order today and save with parts that last.

Chevrolet Silverado 1500 Brake Disc Parts and Q&A

Rotor
15712801
Q: How to replace the front brake disc on the 1500 Series on Chevrolet Silverado 1500?
A:
Begin the front Brake Disc replacement process by having the rotor resurfacing kit (J 41013) and wheel hub resurfacing kit (J 42450-A). First check the brake master cylinder fluid level and drain fluid until the mark reaches the middle point. Take off the wheel and tire unit to record how the disc sits against the hub. Place two big c-clamps on the brake caliper pistons to compress them before taking out the caliper bracket bolts. Keep the caliper assembly supported below the hydraulic brake hose rather than disconnecting it. Detach the Brake Disc retaining parts from inside the wheel if necessary while putting a deadblow hammer to separate the hub or disc from each other. Remove all rust and debris from the hub/axle flange and Brake Disc contact surfaces using j 42450-a wheel hub resurfacing kit and j 41013 rotor resurfacing kit. Rephrase verbalization when possible. Check if the disc removal with jack screw method made nicks on the hub flange while inspecting the mating areas. At last place the disc over the hub and fasten it using the Brake Disc screw until the torque reaches 12nm (106 inch lbs.). The assembled lateral runout measurement of the disc should be taken, and adjustments should be made when needed. Reinstall the caliper and bracket together while applying threadlocker gm 12345493 to the bolts and tightening them to 180 nm (133 ft.lbs.). Put the tire wheel assembly back in place after lowering the vehicle and apply the brake pedal slowly with the engine stopped. Adjust caliper pistons and pads by topping up clean brake fluid when needed.
Rotor, Front
15942195
Q: How can the assembled lateral runout (LRO) of the front brake disc be corrected on Chevrolet Silverado 1500?
A:
To adjust the collected lateral runout (LRO) of the Brake Disc, initially ensure that an examination is done on the Brake Disc thickness, as whenever exceeded, brake pulsation is ensured. Start the measuring process by removing the conical Brake Disc washers (J 45101-100) and the lug nuts that were inserted at the time of the lro measurement. Check the mating surface of hub/axle flange and Brake Disc for any foreign particles or debris. Next, index the Brake Disc in another orientation to the resultant hub/axle flange, hold it in position and install one (1) conical Brake Disc washer (J 45101-100) and one (1) lug nut to the upper-most wheel stud, tightening the lug nut firmly by hand. Continue to retain the disc and install the balance conical Brake Disc washers (J 45101-100) and lug nuts to the brake studs with moderate hand tightening in a star shape. With the torque-limiting socket set (J 39544-KIT), torque the lug nuts in a star fashion to specification to correctly fasten the disc. Yes, take the lro that has been assembled and measure it and compare to the original prior to cleaning while keeping in mind that we have to take repeated measurements and hold it at a perpendicular alignment to obtain accurate reading. If measurement is within specifications, install the brake caliper and operate the brake pedal several times to lock the disc before installing the conical Brake Disc washers (J 45101-100) and lug nuts. When the measurement is outside specification, repeat the indexing and tightening until the best assembled lro measurement is achieved, and matchmark the final position of the disc to the wheel studs, if the orientation is differing from the original.